Food Establishment Inspection Report
Page 1  of ????????? 
KANKAKEE COUNTY HEALTH DEPARTMENT
 2390 W. Station Street
Kankakee, IL 60901
Phone: (815) 802 - 9410
Establishment
 GONZALEZ GROCERY 		License/Permit #
 KK071
Street Address
1933 E COURT ST
City/State
 KANKAKEE, IL 		ZIP Code
 60901
No. of Risk Factor/Intervention Violations 2
No. of Repeat Risk Factor/Intervention Violations 0
Date 03/26/2021
Time In 01:15 PM
Time Out 03:50 PM
Permit Holder
CALDERON, LILIANA 		Risk Category
H
Purpose of Inspection
ORIGINAL INSPECTION

FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
Circle designated compliance status (IN, OUT, N/O, N/A) for each numbered item
IN=in compliance    OUT=not in compliance    N/O=not observed    N/A=not applicable
Mark "X" in appropriate box for COS and/or R
COS=corrected on-site during inspection    R=repeat violation 		Risk factors are important practices or procedures identified as the most prevalent contributing factors of foodborne illness or injury. Public health interventions are control measures to prevent foodborne illness or injury.
Compliance Status
 COS R

SUPERVISION

 
1 IN OUT     Person in charge present, demonstrates knowledge, and performs duties    
2 IN OUT N/A   Certified Food Protection Manager    

EMPLOYEE HEALTH

 
3 IN OUT     Management, food employee and conditional employee; knowledge, responsibilities and reporting    
4 IN OUT     Proper use of restriction and exclusion    
5 IN OUT     Procedures for responding to vomiting and diarrheal events    

GOOD HYGIENIC PRACTICES

 
6 IN OUT   N/O Proper eating, tasting, drinking, or tobacco use    
7 IN OUT   N/O No discharge from eyes, nose, and mouth    

PREVENTING CONTAMINATION BY HANDS

 
8 IN OUT   N/O Hands clean & properly washed    
9 IN OUT N/A N/O No bare hand contact with RTE food or a pre-approved alternative procedure properly allowed    
10 IN OUT     Adequate handwashing sinks properly supplied and accessible    

APPROVED SOURCE

 
11 IN OUT     Food obtained from approved source    
12 IN OUT N/A N/O Food received at proper temperature    
13 IN OUT     Food in good condition, safe, & unadulterated    
14 IN OUT N/A N/O Required records available: shellstock tags, parasite destruction    
Compliance Status
 COS R

PROTECTION FROM CONTAMINATION

 
15 IN OUT N/A N/O Food separated and protected    
16 IN OUT N/A   Food-contact surfaces: cleaned & sanitized    
17 IN OUT     Proper disposition of returned, previously served, reconditioned & unsafe food    

TIME/TEMPERATURE CONTROL FOR SAFETY

 
18 IN OUT N/A N/O Proper cooking time & temperatures    
19 IN OUT N/A N/O Proper reheating procedures for hot holding    
20 IN OUT N/A N/O Proper cooling time and temperature    
21 IN OUT N/A N/O Proper hot holding temperatures    
22 IN OUT N/A N/O Proper cold holding temperatures    
23 IN OUT N/A N/O Proper date marking and disposition    
24 IN OUT N/A N/O Time as a Public Health Control; procedures & records    

CONSUMER ADVISORY

 
25 IN OUT N/A   Consumer advisory provided for raw/undercooked food    

HIGHLY SUSCEPTIBLE POPULATIONS

 
26 IN OUT N/A   Pasteurized foods used; prohibited foods not offered    

FOOD/COLOR ADDITIVES AND TOXIC SUBSTANCES

 
27 IN OUT N/A   Food additives: approved and properly used    
28 IN OUT N/A   Toxic substances properly identified, stored, & used    

CONFORMANCE WITH APPROVED PROCEDURES

 
29 IN OUT N/A   Compliance with variance/specialized process/HACCP    

GOOD RETAIL PRACTICES
Good Retail Practices are preventative measures to control the addition of pathogens, chemicals, and physical objects into foods.
Mark "X" in appropriate box for COS and/or R      
COS
=corrected on site during inspection  
R
=repeat violation  
Compliance Status
 COS R

SAFE FOOD AND WATER

 
30   Pasteurized eggs used where required    
31   Water & ice from approved source    
32   Variance obtained for specialized processing methods    

FOOD TEMPERATURE CONTROL

 
33   Proper cooling methods used; adequate equipment for temperature control    
34   Plant food properly cooked for hot holding    
35   Approved thawing methods used    
36 X Thermometers provided & accurate    

FOOD IDENTIFICATION

 
37   Food properly labeled; original container    

PREVENTION OF FOOD CONTAMINATION

 
38   Insects, rodents, & animals not present    
39   Contamination prevented during food preparation, storage & display    
40   Personal cleanliness    
41   Wiping cloths: properly used & stored    
42   Washing fruits & vegetables    

PROPER USE OF UTENSILS

 
43 X In-use utensils: properly stored X  
Compliance Status
 COS R

PROPER USE OF UTENSILS

 
44   Utensils, equipment & linens: properly stored, dried, & handled    
45   Single-use/single-service articles: properly stored & used    
46   Gloves used properly    

UTENSILS, EQUIPMENT, AND VENDING

 
47 X Food & non-food contact surfaces cleanable, properly designed, constructed & used    
48   Warewashing facilities: installed, maintained & used; test strips    
49 X Non-food contact surfaces clean    

PHYSICAL FACILITIES

 
50   Hot & cold water available; adequate pressure    
51   Plumbing installed; proper backflow devices    
52   Sewage & waste water properly disposed    
53   Toilet facilities: properly constructed, supplied, & cleaned    
54   Garbage & refuse properly disposed; facilities maintained    
55   Physical facilities installed, maintained & clean    
56 X Adequate ventilation & lighting; designated areas used    

EMPLOYEE TRAINING

 
57   All food employees have food handler training    
58 X Allergen training as required    
IOCI 17-356

Food Establishment Inspection Report
Page 2  of ?????? 
Establishments: GONZALEZ GROCERY Establishment #: KK071
Water Supply:   Public Private   Waste Water System:   Public Private
Sanitizer Type: Chemical PPM: CHLORINE: 50 Heat: N/A °F
CFPM Verification (name, ID#, expiration date):


01/01/1900

01/01/1900

01/01/1900

 

TEMPERATURE OBSERVATIONS
Item/Location
Temp
Item/Location
Temp
Item/Location
Temp
/victory cooler ( reach-in cooler) - kitchen 40.00°F /frigidaire freezer - kitchen -1.00°F /u-star cooler - kitchen 40.00°F
/retail ice-cream chest freezer -1.00°F /retail coolers (3x) 35.00°F /retail chest freezer -1.00°F
/butcher's display case - retail 35.00°F /chest freezers (4x) - meat cutting dept. -5.00°F /chest freezers (3x) - dry storage -5.00°F
/kenmore stand-up unit - cooler compartment 33.00°F /kenmore stand-up unit - freezer compartment -1.00°F /walk-in cooler 35.00°F

OBSERVATIONS AND CORRECTIVE ACTIONS
Item
Number 		Severity Violations cited in this report must be corrected within the time frames below.
3 PF Employee illness reporting agreement not available for inspection. In violation of 2-103.11(N): Food employees and conditional employees are informed in a verifiable manner of their responsibility to report in accordance with Law, to the Person in charge, information about their health and activities as they relate to diseases that are transmissible through food, as specified under 2-201.11(A); In violation of 2-103.11(O): written procedures and plans, where specified by the Code and as developed by the Food establishment, are maintained and implemented as required. Corrective Action: The establishment shall have documentation that provides evidence that employees have been informed of their responsibility to report information about their health and activities as they relate to diseases that are transmissible through food to the person in charge. - (Correct By: Apr 7, 2021)
5 PF 2-501.11: A FOOD ESTABLISHMENT shall have procedures for EMPLOYEES to follow when responding to vomiting or diarrheal events that involve the discharge of vomitus or fecal matter onto surfaces in the FOOD ESTABLISHMENT. The procedures shall address the specific actions EMPLOYEES must take to minimize the spread of contamination and the exposure of EMPLOYEES, consumers, FOOD, and surfaces to vomitus or fecal matter.
bodily fluid clean-up kit is not available onsite. In addition, standard operating procedure is also not available. [NOTE: a standard operating procedure has been provided to the facility]. - (Correct By: Apr 7, 2021)
36 C 4-204.112 (B-C): (B) Except as specified in¶(C) of this section, cold or hot holding EQUIPMENT used for TIME/TEMPERATURE CONTROL FOR SAFETY FOOD shall be designed to include and shall be equipped with at least one integral or permanently affixed TEMPERATURE MEASURING DEVICE that is located to allow easy viewing of the device's temperature display. 4-204.112 Temperature Measuring Devices.(C) Paragraph (B) of this section does not apply to EQUIPMENTfor which the placement of a TEMPERATURE MEASURING DEVICE is not a practical means for measuring the ambient air surrounding the FOOD because of the design, type, and use of the EQUIPMENT, such as calrod units, heat lamps, cold plates, bainmaries, steam tables, insulated FOOD transport containers, and salad bars.
no thermometer within walk-in cooler. - (Correct By: Apr 7, 2021)
43 C 3-304.12 (E): During pauses in FOOD preparation or dispensing, FOOD preparation and dispensing UTENSILS shall be stored: (E) In a clean, protected location if the UTENSILS, such as ice scoops, are used only with a FOOD that is not TIME/TEMPERATURE CONTROL FOR SAFETY FOOD.
ice scoop used at the ice machine located at the backroom kitchen was observed to be stored on top of the unclean ice machine. - COS (Correct By: Mar 26, 2021)
47 PF 4-101.11 (D): Materials that are used in the construction of UTENSILS and FOOD-CONTACT SURFACES of EQUIPMENT may not allow the migration of deleterious substances or impart colors, odors, or tastes to FOOD and under normal use conditions shall be: (D) Finished to have a SMOOTH, EASILY CLEANABLE surface.
Observed the cutting board primarily used by the butchers at the meat cutting department to have deep, discolored, and excessive knife grooves covering its surface. - (Correct By: Apr 7, 2021)
49 C 4-602.13: NonFOOD-CONTACT SURFACES of EQUIPMENT shall be cleaned at a frequency necessary to preclude accumulation of soil residues.
Observed the hand washing station located at the butcher's station to be unclean. correct by the next routine inspection.
56 C 6-202.11 (A): (A) Except as specified in ¶ (B) of this section, light bulbs shall be shielded, coated, or otherwise shatter-resistant in areas where there is exposed FOOD; clean EQUIPMENT, UTENSILS, and LINENS; or unwrapped SINGLE-SERVICE and SINGLE-USE ARTICLES.
lights above the backroom kitchen, located above the cooking area, are not shielded. correct by the next routine inspection.
58 C certified food protection managers have not completed allergen awareness training. Complete by the next routine inspection.
Inspection Comments   INSPECTION WAS CONDUCTED ALONGSIDE THE INSPECTION OF 'GONAZALEZ TACOS MOBILE UNIT'

ALLERGEN AWARENESS TRAINING MAY BE COMPLETED THROUGH ANY ANSI CERTIFIED COURSE.
HACCP Topic: PROPER REHEATED TEMPERATURES: REHEAT FOOD PRODUCT TO 165F (MINIMUM), AND FOOD PRODUCT MAY ONLY BE REHEATED ONE TIME.
 

Person In Charge

  GIZELLE AVALOS 		 

Date:

  03/26/2021
 

Inspector

  Alan Hatia 		 

Follow-up:  Yes   No   Follow-up Date:

04/07/2021